History

The rapid economic expansion of the greater Johannesburg area in the 1960s and 70s put its water supply under long term threat and it was decided to redirect water from the large Tugela River which was going largely un-used into the sea and store it in large strategic water storage reservoir with very low evaporation. The initial site chosen for this project was in the adjacent valley to the west on the Elands River. This was the preferred option from an engineering aspect because it would involve a smaller dam wall. However shortly before construction was about to start the site on the Nuwejaarspruit was selected for political reasons because it avoided the partial flooding of the newly planned Bantustan of Qwaqwa in Phuthadichaba. It could have meant this strategic national resource could have been located in a "foreign country" which would have been unacceptable as seen from the perspective of the current government in that time.

Construction

Construction began in 1969 and the first phase was commissioned in 1977 and comprised a 69-metre (226 ft) high earthfill embankment 2,290 metres (7,510 ft) long with no spillway. After completion of the first phase the decision was made to immediately continue with the final phase and it was subsequently raised in 1980 to its current height of 93 metres (305 ft) with a crest length of 3,060 metres (10,040 ft) and a full supply capacity of 2,656 million cubic metres (2,153,000 acre⋅ft). At full supply, it has a surface area of no more than 70 km². The extended dam was commissioned in 1980, and has a capacity of 2,616,950 cubic metres (2,121.60 acre⋅ft), with a surface area of only 67.26 square kilometres (25.97 sq mi), the dam wall is 93 metres (305 ft) high. The total construction period was 11 years. The Sterkfontein Dam was designed and constructed by the Department of Water Affairs. The dam mainly serves for domestic and industrial use and its hazard potential has been ranked high (3).

Naming

The dam was named after one of the farms located in the vicinity of its construction. The temporary township for the construction workers was built on the Sterkfontein farm. The word sterkfontein means strong spring in Afrikaans.

Earth fill dam wall

The wall is an earth gravity type. The dam wall contains 19.8 million cubic metres (700×10^⁶ cu ft) of material making it the largest dam wall in South Africa with regard to volume. The reservoir is impounded by two walls. The second wall is 600 metres (2,000 ft) long and contains 1.04 million cubic metres (37×10^⁶ cu ft) of material.

No spillway

The dam is unique as the majority of water is sourced by diverting flow from the upper reaches of the Tugela river. This water would otherwise be underutilised and flow into the ocean. The dam was not built on a river but instead, it is sited on what can at best be classed as a large stream in the upper reaches of a valley on the Nuwejaarspruit. The catchment area of the dam is less than three times the water surface area of the dam and therefore not risk to a flood. For this reason the main dam wall does not have the need for a spillway. Any excess rainwater can be safely ejected from its outlet valves. The advantage of this location is the Dam is a highly effective reservoir, since it has the depth to store a large amount of water, with very little loss to evaporation. The Vaal Dam lake (reservoir) by comparison has a large surface area and is relatively shallow, which results in a higher rate of evaporation. It would take 17 years of rainfall to fill the dam. But capturing rainfall was not an important intent behind this project. It was built to capture water from the Tugela river and deliver it into the Vaal system.

Pumped Hydro Storage Scheme

Map of the Pumped Storage Scheme

The dam receives its water via the Tugela-Vaal Water Project later renamed the Drakensberg Pumped Storage Scheme which is a 1,000 MW pumped hydro storage scheme involving the net transfer of up to 630 million cubic metres (510,000 acre⋅ft) of water from KwaZulu-Natal. This is stored in the Sterkfontein Dam and released to the Vaal Dam via the Wilge River when needed.

A dam within a dam

The weir separating the Sterkfontein Dam from the Driekloof Dam

The Driekloof Dam which is inside the Sterkfontein Dam, is regarded as a separated dam and reservoir, and is not included in the above figures. It is essentially a dam within a dam. Driekloof Dam is the upper storage reservoir of the Drakensberg Pumped Storage Scheme. If the Sterkfontein Dam were to be empty the Driekloof reservoir would retain the water for the pumped storage scheme to operate unimpeded. When Sterkfontein Dam is at full capacity the Driekloof Dam is submerged up to the top of its spillway.

Third largest dam in South Africa

This is the 3rd largest dam in South Africa in terms of water capacity and it is slightly larger than Vaal Dam.

• Gariep Dam 5,340,600 MegaL
• Vanderkloof Dam 3,171,300 MegaL
• Sterkfontein Dam 2,616,900 MegaL
• Vaal Dam 2,603,400 MegaL