Aqua regia[lower-alpha 1]
Names
IUPAC name
Nitric acid hydrochloride
Other names
  • Aqua regis
  • Nitrohydrochloric acid
  • Royal water
Identifiers
3D model (JSmol)
UNII
  • [N+](=O)(O)[O-].Cl.Cl.Cl
Properties
HNO3 + 3 HCl
Appearance Fuming liquid. Freshly prepared aqua regia is colorless, but it turns yellow, orange or red within seconds.
Density 1.01–1.21 g/cm3
Melting point −42 °C (−44 °F; 231 K)
Boiling point 108 °C (226 °F; 381 K)
Miscible
Vapor pressure 21 mbar
Hazards
NFPA 704 (fire diamond)
NFPA 704 four-colored diamond
3
0
0
OX
Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
Infobox references
Freshly prepared aqua regia to remove metal salt deposits
Freshly prepared aqua regia is colorless, but it turns orange within seconds. Here, fresh aqua regia has been added to these NMR tubes to remove all traces of organic material.

Aqua regia (/ˈreɪɡiə, ˈriːdʒiə/; from Latin, literally "regal water" or "royal water") is a mixture of nitric acid and hydrochloric acid, optimally in a molar ratio of 1:3.[lower-alpha 2] Aqua regia is a fuming liquid. Freshly prepared aqua regia is colorless, but it turns yellow, orange or red within seconds from the formation of nitrosyl chloride and nitrogen dioxide. It was named by alchemists because it can dissolve the noble metals gold and platinum, though not all metals.

Preparation and decomposition

Upon mixing of concentrated hydrochloric acid and concentrated nitric acid, chemical reactions occur. These reactions result in the volatile products nitrosyl chloride and chlorine gas:

HNO3 + 3 HCl → NOCl + Cl2 + 2 H2O

as evidenced by the fuming nature and characteristic yellow color of aqua regia. As the volatile products escape from solution, aqua regia loses its potency. Nitrosyl chloride (NOCl) can further decompose into nitric oxide (NO) and elemental chlorine (Cl2):

2 NOCl → 2 NO + Cl2

This dissociation is equilibrium-limited. Therefore, in addition to nitrosyl chloride and chlorine, the fumes over aqua regia also contain nitric oxide (NO). Because nitric oxide readily reacts with atmospheric oxygen, the gases produced also contain nitrogen dioxide, NO2 (red fume):

2 NO + O2 → 2 NO2

Applications

Aqua regia is primarily used to produce chloroauric acid, the electrolyte in the Wohlwill process for refining the highest purity (99.999%) gold.

Aqua regia is also used in etching and in specific analytic procedures. It is also used in some laboratories to clean glassware of organic compounds and metal particles. This method is preferred among most over the more traditional chromic acid bath for cleaning NMR tubes, because no traces of paramagnetic chromium can remain to spoil spectra.[1] While chromic acid baths are discouraged because of the high toxicity of chromium and the potential for explosions, aqua regia is itself very corrosive and has been implicated in several explosions due to mishandling.[2]

Because its components react quickly, resulting in its decomposition, aqua regia quickly loses its effectiveness (yet remains a strong acid), so its components are usually only mixed immediately before use.

Chemistry

Dissolving gold

Pure gold precipitate produced by the aqua regia chemical refining process

Aqua regia dissolves gold, although neither constituent acid will do so alone. Nitric acid is a powerful oxidizer, which will actually dissolve a virtually undetectable amount of gold, forming gold(III) ions (Au3+). The hydrochloric acid provides a ready supply of chloride ions (Cl−), which react with the gold ions to produce tetrachloroaurate(III) anions ([AuCl4]−), also in solution. The reaction with hydrochloric acid is an equilibrium reaction that favors formation of tetrachloroaurate(III) anions. This results in a removal of gold ions from solution and allows further oxidation of gold to take place. The gold dissolves to become chloroauric acid. In addition, gold may be dissolved by the chlorine present in aqua regia. Appropriate equations are:

Au + 3 HNO
3 + 4 HCl [AuCl
4]−
 + 3 NO
2 + H
3O+
 + 2 H
2O

or

Au + HNO
3 + 4 HCl [AuCl
4]−
 + NO + H
3O+
 + H
2O.

Solid tetrachloroauric acid may be isolated by evaporating the excess aqua regia, and decomposing the residual nitric acid by repeatedly heating the solution with additional hydrochloric acid. That step reduces nitric acid (see decomposition of aqua regia). If elemental gold is desired, it may be selectively reduced with reducing agents such as sulfur dioxide, hydrazine, oxalic acid, etc.[3] The equation for the reduction of oxidized gold (Au3+) by sulfur dioxide (SO2) is the following:

2 [AuCl4]−(aq) + 3 SO2(g) + 6 H2O(l) → 2 Au(s) + 12 H+(aq) + 3 SO2−4(aq) + 8 Cl−(aq)


Dissolution of gold by aqua regia.
Initial state of the transformation.
Intermediate state of the transformation.
Final state of the transformation.

Dissolving platinum

Similar equations can be written for platinum. As with gold, the oxidation reaction can be written with either nitric oxide or nitrogen dioxide as the nitrogen oxide product:

Pt(s) + 4 NO−3(aq) + 8 H+(aq) → Pt4+(aq) + 4 NO2(g) + 4 H2O(l)
3 Pt(s) + 4 NO−3(aq) + 16 H+(aq) → 3 Pt4+(aq) + 4 NO(g) + 8 H2O(l)

The oxidized platinum ion then reacts with chloride ions resulting in the chloroplatinate ion:

Pt4+(aq) + 6 Cl−(aq) → [PtCl6]2−(aq)

Experimental evidence reveals that the reaction of platinum with aqua regia is considerably more complex. The initial reactions produce a mixture of chloroplatinous acid (H2[PtCl4]) and nitrosoplatinic chloride ([NO]2[PtCl4]). The nitrosoplatinic chloride is a solid product. If full dissolution of the platinum is desired, repeated extractions of the residual solids with concentrated hydrochloric acid must be performed:

2 Pt(s) + 2 HNO3(aq) + 8 HCl(aq) → [NO]2[PtCl4](s) + H2[PtCl4](aq) + 4 H2O(l)

and

[NO]2[PtCl4](s) + 2 HCl(aq) ⇌ H2[PtCl4](aq) + 2 NOCl(g)

The chloroplatinous acid can be oxidized to chloroplatinic acid by saturating the solution with molecular chlorine (Cl2) while heating:

H2[PtCl4](aq) + Cl2(g) → H2[PtCl6](aq)

Dissolving platinum solids in aqua regia was the mode of discovery for the densest metals, iridium and osmium, both of which are found in platinum ores and are not dissolved by aqua regia, instead collecting as insoluble metallic powder (elemental Ir, Os) on the base of the vessel.


Dissolution of platinum[lower-alpha 3] by aqua regia.
Initial state of the transformation.
Intermediate state of the transformation.
Final state of the transformation
(four days later).

Precipitating dissolved platinum

As a practical matter, when platinum group metals are purified through dissolution in aqua regia, gold (commonly associated with PGMs) is precipitated by treatment with iron(II) chloride. Platinum in the filtrate, as hexachloroplatinate(IV), is converted to ammonium hexachloroplatinate by the addition of ammonium chloride. This ammonium salt is extremely insoluble, and it can be filtered off. Ignition (strong heating) converts it to platinum metal:[4]

3 [NH4]2[PtCl6] → 3 Pt + 2 N2 + 2 [NH4]Cl + 16 HCl

Unprecipitated hexachloroplatinate(IV) is reduced with elemental zinc, and a similar method is suitable for small scale recovery of platinum from laboratory residues.[5]

Reaction with tin

Aqua regia reacts with tin to form tin(IV) chloride, containing tin in its highest oxidation state:

4 HCl + 2 HNO3 + Sn → SnCl4 + NO2 + NO + 3 H2O

Reaction with other substances

It can react with iron pyrite to form Iron(III) chloride:

FeS2 + 5 HNO3 + 3 HCl → FeCl3 + 2 H2SO4 + 5 NO + 2 H2O

History

Aqua regia first appeared in the De inventione veritatis ("On the Discovery of Truth") by pseudo-Geber (after c. 1300), who produced it by adding sal ammoniac (ammonium chloride) to nitric acid.[6][lower-alpha 4] The preparation of aqua regia by directly mixing hydrochloric acid with nitric acid only became possible after the discovery in the late sixteenth century of the process by which free hydrochloric acid can be produced.[8]

The fox in Basil Valentine's Third Key represents aqua regia, Musaeum Hermeticum, 1678

The third of Basil Valentine's keys (c. 1600) shows a dragon in the foreground and a fox eating a rooster in the background. The rooster symbolizes gold (from its association with sunrise and the sun's association with gold), and the fox represents aqua regia. The repetitive dissolving, heating, and redissolving (the rooster eating the fox eating the rooster) leads to the buildup of chlorine gas in the flask. The gold then crystallizes in the form of gold(III) chloride, whose red crystals Basil called "the rose of our masters" and "the red dragon's blood".[9] The reaction was not reported again in the chemical literature until 1895.[10]

Antoine Lavoisier called aqua regia nitro-muriatic acid in 1789.[11]

When Germany invaded Denmark in World War II, Hungarian chemist George de Hevesy dissolved the gold Nobel Prizes of German physicists Max von Laue (1914) and James Franck (1925) in aqua regia to prevent the Nazis from confiscating them. The German government had prohibited Germans from accepting or keeping any Nobel Prize after jailed peace activist Carl von Ossietzky had received the Nobel Peace Prize in 1935. De Hevesy placed the resulting solution on a shelf in his laboratory at the Niels Bohr Institute. It was subsequently ignored by the Nazis who thought the jar—one of perhaps hundreds on the shelving—contained common chemicals. After the war, de Hevesy returned to find the solution undisturbed and precipitated the gold out of the acid. The gold was returned to the Royal Swedish Academy of Sciences and the Nobel Foundation. They re-cast the medals and again presented them to Laue and Franck.[12][13]

See also

  • Green death – Aggressive solution used to test the resistance of metals to corrosion
  • Piranha solution – Oxidizing acid mixture containing sulfuric acid and hydrogen peroxide sometimes also used to clean glassware

Notes

  1. ↑ The information in the infobox is specific to a molar ratio of 1:3 between nitric acid and hydrochloric acid.
  2. ↑ The relative concentrations of the two acids in water differ; values could be 65% w/v for nitric acid and 35% w/v for hydrochloric acid – that is, the actual HNO3:HCl mass ratio is less than 1:2.
  3. ↑ A platinum Soviet commemorative coin to be precise.
  4. ↑ However, Ahmad Y. Al-Hassan (2005) claimed that Islamic texts dated to before the 13th century, including the works of Jabir ibn Hayyan and Abu Bakr al-Razi, did in fact contain detailed descriptions of aqua regia.[7]

References

  1. ↑ Hoffman, R. (10 March 2005) How to make an NMR sample, Hebrew University. Accessed 31 October 2006.
  2. ↑ American Industrial Hygiene Association, Laboratory Safety Incidents: Explosions. Accessed 8 September 2010.
  3. ↑ Renner, Hermann; Schlamp, Günther; Hollmann, Dieter; Lüschow, Hans Martin; Tews, Peter; Rothaut, Josef; Dermann, Klaus; Knödler, Alfons; et al. "Gold, Gold Alloys, and Gold Compounds". Ullmann's Encyclopedia of Industrial Chemistry. Weinheim: Wiley-VCH. doi:10.1002/14356007.a12_499. ISBN 978-3527306732.
  4. ↑ Hunt, L. B.; Lever, F. M. (1969). "Platinum Metals: A Survey of Productive Resources to industrial Uses" (PDF). Platinum Metals Review. 13 (4): 126–138.
  5. ↑ Kauffman, George B.; Teter, Larry A.; Rhoda, Richard N. (1963). "Recovery of Platinum from Laboratory Residues". Inorganic Syntheses. 7: 232–236. doi:10.1002/9780470132388.ch61. ISBN 978-0-470-13238-8.
  6. ↑ Karpenko, Vladimír; Norris, John A. (2002). "Vitriol in the History of Chemistry". Chemické listy. 96 (12): 997–1005. p. 1002. As Karpenko & Norris note, the uncertain dating of the pseudo-Geber corpus (which was probably written by more than one author) renders the dating of aqua regia equally uncertain.
  7. ↑ Ahmad Y. Al-Hassan, Cultural contacts in building a universal civilisation: Islamic contributions, published by O.I.C. Research Centre for Islamic History, Art and Culture in 2005 and available online at History of Science and Technology in Islam
  8. ↑ Multhauf, Robert P. (1966). The Origins of Chemistry. London: Oldbourne. p. 208, note 29; cf. p. 142, note 79.
  9. ↑ Principe, Lawrence M. (2013). The Secrets of Alchemy. Chicago: University of Chicago Press. ISBN 978-0-226-68295-2. pp. 149-153.
  10. ↑ Rose, Thomas Kirke (1895). "The Dissociation of Chloride of Gold". Journal of the Chemical Society. 67: 881–904. doi:10.1039/CT8956700881. Cf. Principe 2013, p. 152.
  11. ↑ Lavoisier, Antoine (1790). Elements of Chemistry,. in a New Systematic Order, Containing All the Modern Discoveries. Edinburgh: William Creech. p. 116. ISBN 978-0-486-64624-4..
  12. ↑ "Adventures in radioisotope research", George Hevesy
  13. ↑ Birgitta Lemmel (2006). "The Nobel Prize Medals and the Medal for the Prize in Economics". The Nobel Foundation.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.